New here......My 3 Door Cosworth
Discussion
FULL SPEC..........
ENGINE
200 COSWORTH BLOCK
STANDARD STEEL CRANK, STANDARD STEEL CON RODS
GENUINE COSWORTH PISTONS
LOW COMPRESSION (7.6:1)
HIGH PRESSURE 4x4 OIL PUMP
BIG WINGED SUMP (1.5 litres extra)
WRC METAL 4 LAYER HEAD GASKET
LONG STUDDED
4X4 POLISHED & PORTED HEAD
HARVEY GIBBS CAMS
KENT ADJUSTABLE VERNIERS
4X4 MANIFOLD
GT28 ROLLER BEARING TURBO WITH MODIFIED T34 FRONT HOUSING
PORTED INLET MANIFOLD & PLENUM
GARRETT –31 ACTUATOR
GROUP A CAM BELT
GROUP A COIL
GROUP A K&N CONE FILTER with ALLOY 90 degree bend & SAMCO HOSES
GENUINE RS500 INTERCOOLER WITH MODIFIED T34 FITTINGS
PACE RS500 FAST ROAD RADIATOR (50mm core)
PACE TURBO COOLER
BAILEY MOTORSPORT TURBO OIL FEED & PRE FILTER
SPEC-R GROUP A BREATHER/SEPARATOR SYSTEM
SPEC-R CAMBELT COVER
SPEC-R SWIRL POT
SPEC-R HEADER TANK (with sight glass)
SPEC-R WASHER BOTTLE
SPEC-R WATER COOLED POWER STEERING TANK
9 ROW POWER STEERING FLUID COOLER (with -6 Earls fittings and hoses)
STANT 21-25psi RADIATOR CAP WITH LEVER RELEASE
BLACK SAMCO BOOST & WATER HOSES
BRAIDED FUEL HOSE -6 FRONT TO REAR &RETURN (-6 with Earls fittings and clamps)
7 BAR FUEL PRESSURE GUAGE (in line)
MIKALOR STAINLESS STEEL HOSE CLAMPS THROUGHOUT
2 AIR SCOOPES ABOVE INTERCOOLER WITH DUCTING TO AIR FILTER
MONGOOSE 3in STAINLESS STEEL EXHAUST (with Powerflex hangers)
EXHAUST WRAP ON DOWNPIPE, UP TO 1260 DEGREE C
WEBBER MARELLI LEVEL 8 ECU WITH PECTEL BABY BOARD
PECTEL 12 POSITION BOOST CONTROL (in car)
4 X 403 ‘GREY’ INJECTORS
WRC AIR INJECTORS WITH –4 BRAIDED HOSE AND EARLS FITTINGS
CHAMPION RC 505 WRC SPARK PLUGS (gapped to 29 thous)
WATER INJECTION
044 FUEL PUMP
DOUBLE MAP SENSOR BRACKET, HOLDING 2, 3 BAR MAP SENSORS (1 SPARE)
DOUBLE IGNITION AMPLIFIER PLATES, HOLDING 1 SPARE
FORD MOTORSPORT IGNITION LEADS
MILLERS 10w60 FULLY SYNTHETIC OIL
TRANSMISSION
STANDARD BORG WARNER T5 WITH QUICKSHIFT
CASTROL AUTOMATIC TRANSMISSION FLUID (as standard)
LIGHTENED & BALANCED FLY WHEEL
AP 6 PADDLE, STANDARD FORD COVER
RECONDITIONED PROPSHAFT WITH UPRATED UJ’S
QUAIFE ATB 7 ½ INCH DIFF, 3.65 FINAL DRIVE (standard)
CASTROL EP80W-90 OIL
POWER
405 bhp @ 6030 rpm
397 lbft TORQUE @ 4020 rpm
REV LIMITER : 7100 rpm
PEAKS @ 32 psi, HOLDS 28psi
BUILT & TUNED BY HARVEY GIBBS REBUILT May 2009 BY Kevin Wilkins ADVANCED CARS of SWINDON
MAPPED BY AHMED BAYJOO ON DYNO & IN CAR
BRAKES
FRONT: AP RACING CP5555 6 POT CALIPERS
330mm x 28mm DISCS & BELLS
FERRADO DS2500 PADS
REAR: 4x4 CALIPERS
300mm x 22mm DISCS & BELLS
FERRADO PADS
GOODRIDGE BRAIDED HOSES ALL ROUND
CASTROL SRF DOT 4 BRAKE FLUID
SUSPENSION
FRONT: GAZ COILOVERS
10 INCH SPRING, 325LB
POWERFLEX BUSHES
SPEC-R TWIN BAR STRUT BRACE (chromed)
REAR: GAZ COILOVERS
12 INCH SPRING, 225LB
FORD WISHBONE BUSHES
FORD GROUP N REAR BEAM BUSHES
REAR SHIM KIT
SPEC-R REAR STRUT BRACE
INTERIOR
FULL LEATHER & ALCANTERA RETRIM
RS MOTORSPORT 3 SPOKE STEERING WHEEL
WILLINS 4 POINT HARNESSES
STACK 8000 RPM REV COUNTER
DEFI OIL PRESSURE & TEMPERATURE AND EXHAUST GAS TEMPERATURE
DEFI CONTROLLER (with record and playback)
APEXI 2.5 BAR BOOST GUAGE (with record and playback)
S.E.C.S MONITER
PECTAL 12 POSITION BOOST CONTROL
SPEC-R WATER INJECTION TANK IN BOO
JVC KD-G531 HEAD UNIT
ALPINE 6x9 (in rear shelf)
ALPINE 5” (under front dash)
ALPINE TWEETERS (on dash top)
GENISIS 350 WATT AMP & PHOENIX GOLD 350 WATT AMP (under front seat) FUSION 400 WATT SUB (in rear parcel shelf)
EXTERIOR
FRONT WHEELS : IMAGE DM, BE-SPOKE MADE 7.5" X 17" (modified centre plates)
GOODYEAR EAGLE F1’s 215/40/17
REAR WHEELS : IMAGE DM, BE-SPOKE MADE 8" X 17" (modified centre plates)
GOODYEAR EAGLE F1’s 215/40/17
SPARE WHEEL : IMAGE, BE-SPOKE MADE 7.5" X 17" GOODYEAR EAGLE F1 215/40/17
GENUINE RS500 REAR LOWER SPOILER
GENUINE RS500 FRONT SPLITTER
GENUINE RS500 FOGLIGHT GRILLES, WITH COOL AIR DUCTING TO AIR FILTER & POWER STEERING
SPEC-R REAR BUMPER EXHAUST SHIELD
BLACK FORD BADGES
TINTED WINDOWS & TINTED HEADLIGHTS
The car is currently the highest valued 3dr Cosworth in the RSOC valued at £23,500
ENGINE
200 COSWORTH BLOCK
STANDARD STEEL CRANK, STANDARD STEEL CON RODS
GENUINE COSWORTH PISTONS
LOW COMPRESSION (7.6:1)
HIGH PRESSURE 4x4 OIL PUMP
BIG WINGED SUMP (1.5 litres extra)
WRC METAL 4 LAYER HEAD GASKET
LONG STUDDED
4X4 POLISHED & PORTED HEAD
HARVEY GIBBS CAMS
KENT ADJUSTABLE VERNIERS
4X4 MANIFOLD
GT28 ROLLER BEARING TURBO WITH MODIFIED T34 FRONT HOUSING
PORTED INLET MANIFOLD & PLENUM
GARRETT –31 ACTUATOR
GROUP A CAM BELT
GROUP A COIL
GROUP A K&N CONE FILTER with ALLOY 90 degree bend & SAMCO HOSES
GENUINE RS500 INTERCOOLER WITH MODIFIED T34 FITTINGS
PACE RS500 FAST ROAD RADIATOR (50mm core)
PACE TURBO COOLER
BAILEY MOTORSPORT TURBO OIL FEED & PRE FILTER
SPEC-R GROUP A BREATHER/SEPARATOR SYSTEM
SPEC-R CAMBELT COVER
SPEC-R SWIRL POT
SPEC-R HEADER TANK (with sight glass)
SPEC-R WASHER BOTTLE
SPEC-R WATER COOLED POWER STEERING TANK
9 ROW POWER STEERING FLUID COOLER (with -6 Earls fittings and hoses)
STANT 21-25psi RADIATOR CAP WITH LEVER RELEASE
BLACK SAMCO BOOST & WATER HOSES
BRAIDED FUEL HOSE -6 FRONT TO REAR &RETURN (-6 with Earls fittings and clamps)
7 BAR FUEL PRESSURE GUAGE (in line)
MIKALOR STAINLESS STEEL HOSE CLAMPS THROUGHOUT
2 AIR SCOOPES ABOVE INTERCOOLER WITH DUCTING TO AIR FILTER
MONGOOSE 3in STAINLESS STEEL EXHAUST (with Powerflex hangers)
EXHAUST WRAP ON DOWNPIPE, UP TO 1260 DEGREE C
WEBBER MARELLI LEVEL 8 ECU WITH PECTEL BABY BOARD
PECTEL 12 POSITION BOOST CONTROL (in car)
4 X 403 ‘GREY’ INJECTORS
WRC AIR INJECTORS WITH –4 BRAIDED HOSE AND EARLS FITTINGS
CHAMPION RC 505 WRC SPARK PLUGS (gapped to 29 thous)
WATER INJECTION
044 FUEL PUMP
DOUBLE MAP SENSOR BRACKET, HOLDING 2, 3 BAR MAP SENSORS (1 SPARE)
DOUBLE IGNITION AMPLIFIER PLATES, HOLDING 1 SPARE
FORD MOTORSPORT IGNITION LEADS
MILLERS 10w60 FULLY SYNTHETIC OIL
TRANSMISSION
STANDARD BORG WARNER T5 WITH QUICKSHIFT
CASTROL AUTOMATIC TRANSMISSION FLUID (as standard)
LIGHTENED & BALANCED FLY WHEEL
AP 6 PADDLE, STANDARD FORD COVER
RECONDITIONED PROPSHAFT WITH UPRATED UJ’S
QUAIFE ATB 7 ½ INCH DIFF, 3.65 FINAL DRIVE (standard)
CASTROL EP80W-90 OIL
POWER
405 bhp @ 6030 rpm
397 lbft TORQUE @ 4020 rpm
REV LIMITER : 7100 rpm
PEAKS @ 32 psi, HOLDS 28psi
BUILT & TUNED BY HARVEY GIBBS REBUILT May 2009 BY Kevin Wilkins ADVANCED CARS of SWINDON
MAPPED BY AHMED BAYJOO ON DYNO & IN CAR
BRAKES
FRONT: AP RACING CP5555 6 POT CALIPERS
330mm x 28mm DISCS & BELLS
FERRADO DS2500 PADS
REAR: 4x4 CALIPERS
300mm x 22mm DISCS & BELLS
FERRADO PADS
GOODRIDGE BRAIDED HOSES ALL ROUND
CASTROL SRF DOT 4 BRAKE FLUID
SUSPENSION
FRONT: GAZ COILOVERS
10 INCH SPRING, 325LB
POWERFLEX BUSHES
SPEC-R TWIN BAR STRUT BRACE (chromed)
REAR: GAZ COILOVERS
12 INCH SPRING, 225LB
FORD WISHBONE BUSHES
FORD GROUP N REAR BEAM BUSHES
REAR SHIM KIT
SPEC-R REAR STRUT BRACE
INTERIOR
FULL LEATHER & ALCANTERA RETRIM
RS MOTORSPORT 3 SPOKE STEERING WHEEL
WILLINS 4 POINT HARNESSES
STACK 8000 RPM REV COUNTER
DEFI OIL PRESSURE & TEMPERATURE AND EXHAUST GAS TEMPERATURE
DEFI CONTROLLER (with record and playback)
APEXI 2.5 BAR BOOST GUAGE (with record and playback)
S.E.C.S MONITER
PECTAL 12 POSITION BOOST CONTROL
SPEC-R WATER INJECTION TANK IN BOO
JVC KD-G531 HEAD UNIT
ALPINE 6x9 (in rear shelf)
ALPINE 5” (under front dash)
ALPINE TWEETERS (on dash top)
GENISIS 350 WATT AMP & PHOENIX GOLD 350 WATT AMP (under front seat) FUSION 400 WATT SUB (in rear parcel shelf)
EXTERIOR
FRONT WHEELS : IMAGE DM, BE-SPOKE MADE 7.5" X 17" (modified centre plates)
GOODYEAR EAGLE F1’s 215/40/17
REAR WHEELS : IMAGE DM, BE-SPOKE MADE 8" X 17" (modified centre plates)
GOODYEAR EAGLE F1’s 215/40/17
SPARE WHEEL : IMAGE, BE-SPOKE MADE 7.5" X 17" GOODYEAR EAGLE F1 215/40/17
GENUINE RS500 REAR LOWER SPOILER
GENUINE RS500 FRONT SPLITTER
GENUINE RS500 FOGLIGHT GRILLES, WITH COOL AIR DUCTING TO AIR FILTER & POWER STEERING
SPEC-R REAR BUMPER EXHAUST SHIELD
BLACK FORD BADGES
TINTED WINDOWS & TINTED HEADLIGHTS
The car is currently the highest valued 3dr Cosworth in the RSOC valued at £23,500
The car is with my spanner man, having a full engine rebuild.....
No more power before you ask, its has more than enough for me LOL
While the engine was out I have changed a few things under the bonnet, as soon as the car is home (next week hopefully) I will post some up date piccys
Thanks for the positive comments
Steve
No more power before you ask, its has more than enough for me LOL
While the engine was out I have changed a few things under the bonnet, as soon as the car is home (next week hopefully) I will post some up date piccys
Thanks for the positive comments
Steve
Very nice indeed and good photos too. I'm not a big fan of chroming or additional gauges but I can appreciate a nicely finished Sierra when I see one, and it's clear this car's been done properly. Wheels are very nice indeed and well in keeping with the spirit of the car. Well done fella. Nice to see a tidy motor...!
Gassing Station | Readers' Cars | Top of Page | What's New | My Stuff